Contents
01.12.2017.
Professional paper
Extraction and characterisation of cellulose nanocrystals from pineapple peel
The potential of pineapple peel as a source of cellulose nanocrystals was evaluated. Peels skin from fresh-cut fruit was used as raw material. These residues were purified to remove pigments, lipids and hemicellulose, and a bleaching process for delignification was carried out for 4-6 h. All resulting products were characterised for their lignin, hemicellulose, cellulose and ash contents using standard techniques. Dry matter at the end was low (ca. 50%) compared with the raw material (ca. 90%). The process applied resulted in ca. 20% (m/m) of purified cellulose (ca. 80% purity), with ineligible levels of lignin and hemicellulose present, especially when using 6h of bleaching. The purified cellulose was subject to acid hydrolysis for nanocrystal extraction with two testing times, 30 and 60 minutes. These cellulose nanocrystals had small sizes (< 1000 nm), with high variability and negative zeta potential values. The time of extraction did not affect the nanocrystals’ chemical and physical properties. The use of 6 h of bleaching treatment during purification was shown to be more effective than 4 h. Pineapple peel was demonstrated to be a good source of cellulose for the production of cellulose nanocrystals.
Ana Raquel Madureira, Tuğba Atatoprak, Duygu Çabuk, Flávia Sousa, Robert C. Pullar, Manuela Pintado
01.12.2017.
Professional paper
Quality assessment and shelf life modeling of pulsed electric field pretreated osmodehydrofrozen kiwifruit slices
The objective of this workwas to investigate the potential use of pulsed electric field (PEF) in combination with osmotic dehydration (OD) as a pre-freezing step and to evaluate the effect on quality characteristics and shelf life of frozen kiwifruit. Peeled kiwifruit was subjected to PEF (1.8 kV/cm), sliced and treated in OD-solution [containing glycerol, maltodextrin, trehalose, ascorbic acid, calcium chloride, citric acid, sodium chloride; 1/5 (wfruit/wsolution)] for 30 and 60 min at 35 °C. Combined, PEF only and OD only treated samples as well as nontreated and blanched (80 °C, 60 s) samples were frozen and stored at constant (-5, -10, -15, -25 °C) and dynamic temperature conditions (-18 °C-3 d, -8 °C-2.5 d, -15 °C-3 d). Quality of frozen samples was evaluated by means of drip loss, colour, texture, vitamin C and sensory evaluation (1-9 scale); and shelf life (SL) was calculated. Nontreated and blanched samples presented high drip loss and tissue softening (instrumentally measured as Fmax decrease). The tissue integrity was well retained in all osmotically pretreated samples. PEF pretreatment caused increase of fruit whiteness (increase of L value) and yellowness (a and/or b value increase); SL calculation was based on colour change. All OD samples had high vitamin content (24.6 mg/100 g fresh material compared to 138-154 mg/100 g osmodehydrated material); PEF led to 93% (of the initial) vitamin retention; blanched samples showed the lowest retention (86.9% of the initial) (criteria for SL calculation). OD and combined PEF-OD treatment increased the shelf life of frozen kiwifruit (up to 3 times; based on sensorial criteria). The developed kinetic models for colour change, vitamin loss, and sensory quality deterioration were validated at dynamic temperature conditions. PEF pretreated OD (at significantly shorter time, 30 min compared to 60 min) kiwifruits retained optimum quality and sensory characteristics. PEF and OD could be used as a preprocessing step of good quality, longer shelf life kiwi sliced frozen products.
Efimia Dermesonlouoglou, Ismini Zachariou, Varvara Andreou, Petros S. Taoukis
01.12.2017.
Professional paper
Effect of storage time and gamma irradiation on the chemical properties of olive (Olea europaea) oils
The objective of this study was to investigate the effects of gamma irradiation at doses of 0, 1, 2 and 3 kGy, and storage time of olive fruits for 0, 30 and 45 days on changes in chemical properties of olive oil during storage periods of 0, 6 and 12 months. The initial acidity value (AV), peroxide value (PV), Thiobarbituric Acid (TBA), phenolic content, iodine value (IV), and saponification value (SV) of virgin olive oil obtained from olives fruits immediately after harvest (at day zero) were 1.04%, 3.06 mEqO2 kg-1oil, 0.025 mg MDA kg-1 oil, 314.71 mg gallic acid kg-1 oil, 93.38 gI2 100 g-1 oil and 194.88 mg KOH g-1 oil, respectively. In general, the AV and PV of olive oil was increased by gamma irradiation, while the phenolic and IV of olive oil was deceased by gamma irradiation and storage time. The TBA value and SV of olive oil was not significantly (p>0.05) changed by gamma irradiation.
M. Al-Bachir
01.12.2017.
Professional paper
Food oral processing in humans: links between physiological parameters, release of flavour stimuli and flavour perception of food
In humans, food oral processing (FOP) is the first step in the digestive process. It prepares the food for swallowing and to undergo the process of digestion. During chewing, the food is comminuted by the combined action of chewing and saliva to form a bolus. The particle size of the bolus is reduced due to the action of the tongue and the teeth, and the saliva is continuously produced by the salivary glands to humidify and impregnate the food. Saliva lubricates the bolus and enables the cohesion of particles to prepare for swallowing. During food oral processing, the compounds responsible for food flavour and taste are released, leading to the perception of food organoleptic properties and significantly contributing to the consumer’s acceptability of the product. Understanding this process of food breakdown and bolus formation thus appears to be a way to revisit food functional properties. However, this process is extremely complex, and as such, its description necessitates a combination of many quantities from different disciplines, i.e., physics, chemistry, physiology, psychology, behavioural science and food science. It depends, on one hand, on food properties and on the other hand, it depends on oral physiology. However, large inter-individual variability is commonly observed, which has important consequences on flavour release and perception. The challenge for the food industry is to be able to develop food considering this large variability, and sensory and nutritional constraints. This challenge is particularly relevant when specific populations (i.e., elderly, infants or obese subjects) are considered.
Gilles Feron, Christian Salles
18.04.2017.
Original scientific paper
Effect of pretreatments and processing conditions on anti-nutritional factors in climbing bean flours
It is difficult for many Rwandans to utilize climbing bean seeds (Phaseolus vulgaris L.) mainly because of longer cooking time (2 hours) and the high consumption of basic fuel. Climbing beans also contain anti-nutritional factors such tannins, phytates, trypsin inhibitors and phytohemagglutinins that limit nutrient absorption. One way to solve this problem is to utilize the flour of climbing beans made from different treatments and processing methods. In this study, climbing beans were pre-treated by soaking them in water for 24 hours, soaking in 2% sodium bicarbonate solution and steam blanching for 10 minutes. After that, pre-treated climbing beans were processed into flours by processing methods such as roasting, cooking and germination where anti-nutritional factors were reduced. The pretreatments did not significantly (p>0.05) affect phytates in climbing bean flours but processing conditions significantly (p<0.05) reduced it. Pretreatments and processing conditions significantly (p<0.05) reduced tannin content. The pretreatments followed by different processing conditions significantly (p<0.05) decreased trypsin inhibitors content. The great significant decrease in phytohemagglutinins content was observed in pretreatment followed by different processing methods. All pretreatments and processing conditions effectively decreased anti-nutritional factors at low level. However, pretreatments or untreated followed by germination and roasting were found to be the most and the least effective respectively. Making flour from germinated climbing bean seeds is a good option for sustainable food processing as it reduces anti-nutritional factors. It is an inexpensive method in terms of time, energy and fuel for Rwandan households, restaurants and industries where climbing bean seeds are integral part of daily meal.
Emmanuel Mugabo, Emmanuel Ohene Afoakwa, George Annor, Bernard RWUBATSE
01.12.2016.
Professional paper
Evaluation of physical, milling and cooking properties of four new rice (Oryza sativa L.) varieties in Nigeria
This comparative study investigated some physical, milling and cooking properties of four new rice varieties (FARO 44, FARO 52, FARO 60 and FARO 61) in Nigeria. The varieties were processed into white rice and their properties analyzed separately using standard procedures. Results showed that paddy length, paddy-length-to-width-ratio, equivalent diameter, sphericity, grain volume, aspect ratio, thousand paddy grain weight, milled rice length, milled rice width, milled rice length to width ratio, milling recovery, head milled rice, broken milled rice, L*, a*, b*, elongation ratio, cooked-rice-length-to-breadth-ratio, water uptake ratio and cooking time were significantly different (p<0.05) for all the varieties. Milling recovery was found to vary from 65.3 to 68.33%; with FARO 60 having the highest head milled rice. It was observed that FARO 44 had the longest cooking time, elongation ratio and cooked rice length/breadth ratio while FARO 61 was found to have the highest water uptake ratio. There was significant positive correlation (r = 0.824) between percentage head milled rice and milling recovery while negative correlation existed between cooking time and L* (r= - 0.711). This information could be exploited by rice processors in the post-harvest processing of the varieties.
Mayowa S. Sanusi, Rahman Akinoso, Nahemiah Danbaba
01.12.2016.
Professional paper
Drying characteristics of zucchini and empirical modeling of its drying process
The aim of the study was to dry zucchini (Cucurbita pepo) by two different methods (convective hot-air (CHD) and microwave-assisted drying (MWD)). The effect of air temperature (60, 70 and 80°C), microwave (MW) power (180, 360, 540 W) and sample thickness (5 and 10 mm) on some drying characteristics of zucchini were investigated. Thirteen mathematical models available in the literature were fitted to the experimental moisture ratio data. The coefficients of the models were determined by non-linear regression analysis. It was determined that the model that fits the moisture ratio data the best varies at different drying conditions. Increasing drying temperature and MW power and reducing sample thickness improved the drying rate and drying time. Drying in microwave has reduced the drying time by 52-64% for zucchini. It was found that the effective moisture diffusivities increased with increasing temperature and MW power. MWD samples had better rehydration ratios compared to ones dried only in tray drier for 5 mm thickness.
Naciye Kutlu, Asli Isci
01.12.2016.
Professional paper
Impact of selected polyphenolics on the structural properties of model lipid membranes – a review
This review is a presentation of data gathered on the interactions of several polyphenolics (i.e., phenolic acids, stilbenes, flavonoids) with lipid bilayers of different lipid compositions. These polyphenolics have been investigated through a combination of fluorescence spectroscopy, electron paramagnetic resonance spectroscopy, and differential scanning calorimetry, to detect changes in membrane fluidity. Among the investigated phenolic acids, the least polar phenolic acid, p-coumaric acid, has the greatest effect on lipid membrane structure. It appears to have a greater ability to cross membranes by passive transport than more polar phenolic acids. On the other hand, among the flavonoids that have been studied, the anthocyanins cyanidin 3-glucoside and its aglycone are inactive. All of the flavonols tested, except for epigallocatechin-3-gallate, promote small decreases in membrane fluidity. Computer simulation of electron paramagnetic resonance spectra for flavonoids indicated two or three regions in the phosphatidylcholine/ phosphatidylserine (2.4:1) membrane with different fluidity characteristics. The effects of the different flavonoids are correlated to their structural characteristics, whereby even the difference in one -OH group can be important, as can the number of H-bonds they form. The role of membrane composition and flavonoid structure in these interactions with lipid membranes are of great importance for bioavailability of these compounds and for their biological effects in an organism
Nataša P. Ulrih, Ajda Ota, Veronika Abram
01.12.2016.
Professional paper
Microbial quality and shelf life prediction of vacuum-packaged ready to eat beef rounds containing gum arabic
Research has shown that gum arabic from Acacia senegal var. kerensis can be used in beef rounds, at a level of 2.5% of the formulated product weight, as a binder and texture modifier. However, the effect of gum arabic addition on the microbial quality and shelf life of the resulting meat product has not yet been reported. Thus, the objective of this work was to study the microbial quality of beef rounds containing 2.5% gum arabic and to study shelf life based on the growth parameters of Total Viable Counts (TVC) and Lactic Acid Bacteria (LAB). Beef round samples were injected at 30% with curing brines containing gum arabic and cooked through boiling. The growth kinetics of LAB and TVC were studied for vacuum packaged sliced beef round samples stored at 7 oC and 15 oC for a period of 21 days. Baranyi and modified Gompertz models were used to fit the LAB and TVC data obtained using DMFit. Results of microbial analysis indicated that coliforms, yeasts and molds as well as pathogenic bacteria; Salmonella, Escherichia coli, and Staphylococcus aureus, were below detection limit. In addition, TVC and LAB were found to be 1.87 ± 1.09 and 1.25 ± 0.75 Log 10 CFU g-1, respectively. The results of accuracy analysis showed that both the Baranyi and modified Gompertz models were adequate in representing the bacterial growth in beef rounds injected with curing brines containing gum arabic. The predicted shelf life was found to be between 84.3 – 88.1 h and 158.0 – 173.1 h at 15 oC and 7 oC, respectively.
Johnson K. Mwove, Symon M. Mahungu, Lilian A. Gogo, Ben N. Chikamai, Mary Omwamba
01.12.2016.
Professional paper
Rheological properties of traditional balsamic vinegar: New insights and markers for objective and perceived quality
The molecular structure of Traditional Balsamic Vinegar (TBV) undergoes shear-induced and time-dependent jamming transitions due to the high solute concentration and self-assembling phenomena of high molecular size melanoidins with very-long relaxation times (12 years at least or more than 25). The purpose of this work was to perform a descriptive and quantitativeevaluation of relationships between rheological properties, vinegar composition, and perceptual assessment of sensory properties according to the official sensory procedure. With this aim, vinegars having quality traits matching legal requirements for the PDO designation were analyzed for their reducing sugars (glucose and fructose), volatile acidity, fixed acidity, pH, Brix degree, and density as well as for their flow behaviour and dynamic viscosity over a wide range of shear rates. Results showed that flow behaviour of TBV was affected by jamming properties over wide-scale ranges of shear rate producing flow instability below a shear rate of 60s-1. Homogeneous, continuous flow was found at medium-high shear rates with thickening and/or thinning traits. A common onset for the structure scaling was mathematically estimated to occur close to when the density was 1.32 gmL-1. Comparative analysis of rheological, compositional and sensory properties suggested that the colloidal jamming of the vinegar melanoidins dominated the total olfactive and gustative stimuli, and determined the classification of the vinegars that had a higher dynamic viscosity but more homogeneous flow as being of the highest commercial quality category. A robust statistical model was proposed encoding for the top-down decision-making process for quality assignment according to the official sensory procedure, using composition and flow properties as predictor variables.
Pasquale M. Falcone, Elisa Sabatinelli, Federico Lemmetti, Paolo Giudici
